Electronic Control Unit (ECU)

Slides:



Advertisements
Similar presentations
Request Dispatching for Cheap Energy Prices in Cloud Data Centers
Advertisements

SpringerLink Training Kit
Luminosity measurements at Hadron Colliders
From Word Embeddings To Document Distances
Choosing a Dental Plan Student Name
Virtual Environments and Computer Graphics
Chương 1: CÁC PHƯƠNG THỨC GIAO DỊCH TRÊN THỊ TRƯỜNG THẾ GIỚI
THỰC TIỄN KINH DOANH TRONG CỘNG ĐỒNG KINH TẾ ASEAN –
D. Phát triển thương hiệu
NHỮNG VẤN ĐỀ NỔI BẬT CỦA NỀN KINH TẾ VIỆT NAM GIAI ĐOẠN
Điều trị chống huyết khối trong tai biến mạch máu não
BÖnh Parkinson PGS.TS.BS NGUYỄN TRỌNG HƯNG BỆNH VIỆN LÃO KHOA TRUNG ƯƠNG TRƯỜNG ĐẠI HỌC Y HÀ NỘI Bác Ninh 2013.
Nasal Cannula X particulate mask
Evolving Architecture for Beyond the Standard Model
HF NOISE FILTERS PERFORMANCE
Electronics for Pedestrians – Passive Components –
Parameterization of Tabulated BRDFs Ian Mallett (me), Cem Yuksel
L-Systems and Affine Transformations
CMSC423: Bioinformatic Algorithms, Databases and Tools
Some aspect concerning the LMDZ dynamical core and its use
Bayesian Confidence Limits and Intervals
实习总结 (Internship Summary)
Current State of Japanese Economy under Negative Interest Rate and Proposed Remedies Naoyuki Yoshino Dean Asian Development Bank Institute Professor Emeritus,
Front End Electronics for SOI Monolithic Pixel Sensor
Face Recognition Monday, February 1, 2016.
Solving Rubik's Cube By: Etai Nativ.
CS284 Paper Presentation Arpad Kovacs
انتقال حرارت 2 خانم خسرویار.
Summer Student Program First results
Theoretical Results on Neutrinos
HERMESでのHard Exclusive生成過程による 核子内クォーク全角運動量についての研究
Wavelet Coherence & Cross-Wavelet Transform
yaSpMV: Yet Another SpMV Framework on GPUs
Creating Synthetic Microdata for Higher Educational Use in Japan: Reproduction of Distribution Type based on the Descriptive Statistics Kiyomi Shirakawa.
MOCLA02 Design of a Compact L-­band Transverse Deflecting Cavity with Arbitrary Polarizations for the SACLA Injector Sep. 14th, 2015 H. Maesaka, T. Asaka,
Hui Wang†*, Canturk Isci‡, Lavanya Subramanian*,
Fuel cell development program for electric vehicle
Overview of TST-2 Experiment
Optomechanics with atoms
داده کاوی سئوالات نمونه
Inter-system biases estimation in multi-GNSS relative positioning with GPS and Galileo Cecile Deprez and Rene Warnant University of Liege, Belgium  
ლექცია 4 - ფული და ინფლაცია
10. predavanje Novac i financijski sustav
Wissenschaftliche Aussprache zur Dissertation
FLUORECENCE MICROSCOPY SUPERRESOLUTION BLINK MICROSCOPY ON THE BASIS OF ENGINEERED DARK STATES* *Christian Steinhauer, Carsten Forthmann, Jan Vogelsang,
Particle acceleration during the gamma-ray flares of the Crab Nebular
Interpretations of the Derivative Gottfried Wilhelm Leibniz
Advisor: Chiuyuan Chen Student: Shao-Chun Lin
Widow Rockfish Assessment
SiW-ECAL Beam Test 2015 Kick-Off meeting
On Robust Neighbor Discovery in Mobile Wireless Networks
Chapter 6 并发:死锁和饥饿 Operating Systems: Internals and Design Principles
You NEED your book!!! Frequency Distribution
Y V =0 a V =V0 x b b V =0 z
Fairness-oriented Scheduling Support for Multicore Systems
Climate-Energy-Policy Interaction
Hui Wang†*, Canturk Isci‡, Lavanya Subramanian*,
Ch48 Statistics by Chtan FYHSKulai
The ABCD matrix for parabolic reflectors and its application to astigmatism free four-mirror cavities.
Measure Twice and Cut Once: Robust Dynamic Voltage Scaling for FPGAs
Online Learning: An Introduction
Factor Based Index of Systemic Stress (FISS)
What is Chemistry? Chemistry is: the study of matter & the changes it undergoes Composition Structure Properties Energy changes.
THE BERRY PHASE OF A BOGOLIUBOV QUASIPARTICLE IN AN ABRIKOSOV VORTEX*
Quantum-classical transition in optical twin beams and experimental applications to quantum metrology Ivano Ruo-Berchera Frascati.
The Toroidal Sporadic Source: Understanding Temporal Variations
FW 3.4: More Circle Practice
ارائه یک روش حل مبتنی بر استراتژی های تکاملی گروه بندی برای حل مسئله بسته بندی اقلام در ظروف
Decision Procedures Christoph M. Wintersteiger 9/11/2017 3:14 PM
Limits on Anomalous WWγ and WWZ Couplings from DØ
Presentation transcript:

Electronic Control Unit (ECU) Topics covered in this presentation: ECU Operation ECU Components In Car Position ClassAct SRS enabled.

Electronic Control Unit Also Known as Electronic Control Module (ECM) and Powertrain Control Module (PCM). Vehicle management is by ECU, which acts as a computer. Three stages of operation: INPUT-PROCESS-OUTPUT. Next >

Question 1 Which of these does NOT provide an input to an ECU? A) Display B) Magnetic pickup C) Variable resistor Correct Answer = A D) Switch

ECU Operation Inputs come from sensors and switches. CPU processes input readings and compares with ideal data, stored in memory. Outputs to actuators make adjustments that improve: Efficiency. Power. Controllability. Safety. Next >

Simplified ECU Control System Typical ECU and controls: Q ECU E N D R M L K C A G F O H P J I B A. Engine temp sensor G. Canister purge valve M. Fuel pressure regulator B. Oxygen sensor H. Canister air valve N. Camshaft sensor C. Knock sensor I. Charcoal canister O. Crankshaft sensor D. Mass airflow sensor J. TPS P. Diagnosis lamp E. Vacuum controller K. Air temp sensor Q. Ignition coil F. EGR valve L. Idle actuator R. Injector Next >

Question 2 Which of these is NOT connected to an ECU output? A) Vacuum controller B) Idle actuator C) Fuel pressure regulator D) Engine temperature sensor

ECU Internal Circuits Input circuit conditions signals. Processing circuit compares information. Output circuit switches actuators. Power supply provides stable voltages to circuits. Next >

Question 3 Why is it important to have stable voltages supplied to sensors? A) To avoid damaging the sensors B) To prevent them acting as switches C) To prevent them providing false readings Correct Answer = C D) To prevent them becoming actuators

Processing Circuit Components - The CPU CPU performs decisions and calculations. Contains hundreds of logic gates, which operate with binary numbers. Next >

Question 4 Which of the following is a function of the central processing unit (CPU)? A) Measuring voltages B) Making decisions C) Setting the clock frequency Correct Answer = B D) Manufacturing logic gates

Processing Circuit Components - Memory Read Only Memory (ROM) Contains program to control ECU. Processing components Program is vehicle generic. Information cannot be changed. Random Access Memory (RAM) Temporary memory. Used by CPU to store and retrieve data. Data lost when power removed. Next >

Processing Circuit Components - Memory Programmable Read Only Memory (PROM /EPROM) Program that is vehicle specific. Processing components Can be updated. Read only. Keep Alive Memory (KAM) Stores adaptive strategies. Supplies default data if fault occurs. Data is not lost if vehicle battery disconnected (has own internal battery). Next >

Question 5 Which of the following types of memory will lose data when the power is switched off? A) PROM B) KAM C) ROM Correct Answer = D D) RAM

Question 6 Which type of memory contains generic information to control the ECU? A) ROM B) RAM C) PROM Correct Answer = A D) KAM

ECU Housing and Location Hard metal or plastic case, with a connector(s) for multiple wires. Located away from moisture, heat and vibration. Housing Connectors and wires Next >

Question 7 Moisture is a hazard to ECUs because it can coat insulators and allow them to conduct electricity. Is this true or false? Answer True or False. Correct Answer = T

Different Types of ECU Sometimes split into specific areas. Main ECU Instrument cluster unit Anti-lock brake unit Main ECU Suspension unit Next >

Static Electricity Precautions People can become charged with static electricity. Charge stays until conductive material touched. Static electricity damages internal components of electronic devices (ECU). Touch suitable ground point to discharge. Rubber gloves may prevent static electricity build up and transfer. Next >

Question 8 Static electricity transfer can be prevented by wearing rubber gloves. Is this true or false? Answer True or False. Correct Answer = T

Summary You should be aware of: ECU Operation ECU Components In Car Position End >