Presentation is loading. Please wait.

Presentation is loading. Please wait.

ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 1 Hardware Status and Plans of the Embedded Local Monitor Board Hardware Status.

Published by Modified over 8 years ago

Similar presentations

Presentation on theme: "ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 1 Hardware Status and Plans of the Embedded Local Monitor Board Hardware Status."— Presentation transcript:

1 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 1 Hardware Status and Plans of the Embedded Local Monitor Board Hardware Status and Plans of the Embedded Local Monitor Board

2 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 2 Introduction  to monitor voltages, currents, temperatures,..  to control power supplies, cooling system,...  to read and write status bits  to check in-system programmable devices via serial control e.g. JTAG and I2C via serial control e.g. JTAG and I2C There is a need for a general-purpose Detector Front-End I/O Control System which can be embedded in the detectors.

3 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 3 Introduction to ELMB

4 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 4 Development of the ELMB is motivated by  Radiation Problems Total Ionising Dose TID CMOS MUX Non-Ionising Energy Loss NIEL Optocouplers Single Even Effects SEE Memory bit errors  Magnetic Field (1.5T to 0.1T)  Magnetic Field (1.5T to 0.1T) DC-DC converters  Access restriction - should work 24h and 365 days/year  I/O points distributed over the whole detector volume <100m  Standardised connections to the SCADA Hardware: CANbus / LAN Software: CANopen, OPC, TCP/IP

5 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 5 and furthermore...  Reduced design effort by individual institutes  Common Open Embedded Software templates, libraries  Spares and maintence during the detector lifetime (15 years)  Low power consumption cables, local power supplies  Commercial low cost in ATLAS several thousands will be needed  Common effort People from many subdetectors involved in HW and SW.

6 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 6 ELMB block diagram

7 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 7 ELMB block diagram Alternative to the ADC?

8 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 8 ELMB front side 50mm 66 mm DIP-SW ID BAUD ISP CAN CAN optos ADC optos

9 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 9 ELMB back side ADC 2*50 pin Bergstac connector ADC Analog MUX

10 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 10 ELMB specifications  )  General-purpose plug-on module (50 x 60 mm 2 )  CANbus interface (Full-CAN controller)  CANopen communication protocol  Powerful 8-bit RISC Microcontrollers  In System Programmable also via CAN bus second microcontroller with dedicated tasks  Optional 64 inputs of 16-bit ADC with 7 bit gain  General I/O with 18 I/O, 8 Out and 8 IN (or ADC), 3 wire SPI  Flexible power supply circuits incorporated (4 )  Est. cost is $2 / ch for ADC +CAN

11 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 11 Measurements of the ELMB Current Consumption

12 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 12 Measurements

13 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 13 2.5 to 4V operation of the 5V ELMB

14 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 14 Power ELMB  CAN controller ~20mA @ 5V (CAN specs)  Microcontrollers Digital I/O 5V 33mA 3.3V 15mA  ADC ~10mA @ 5V  OK for operation of the 5V ELMB with digital I/O in a 3.3V system with voltage doubler ADP3607

15 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 15 ELMB ADC

16 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 16 Crystal CS5523 Resolution 16 + 7 Bits CMR DC, 50Hz 120 dB Linearity ± 0.0015% FS Offset ± 2 LSB Stability 20 nV / º C Gain 1 ppm/ º C Delta-Sigma ADC 2 Hz to 100 Hz ±25 mV to ±5 V differential Not Accurate has to be calibrated!

17 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 17 ELMB ADC 1uV

18 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 18 ELMB ADC

19 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 19 High precision temperature principle After calibration ~3 mK precision at ATLAS LAr calorimeter

20 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 20 ELMB Motherboard for prototypes and tests

21 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 21 ELMB motherboard for tests in DIN rail housing

22 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 22 Motherboard  Signal adapaters for PT100, NTC and voltages  18 pin DIL sockets  Plug-in on back-side  One for every 4 inputs  Many type of sensors can be mixed

23 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 23 ELMB Radiation Tolerance Critiera ELMB Radiation Tolerance Critiera according to the ATLAS POLICY ON RADIATION TOLERANT ELECTRONICS ELMB: ----- * Will be used in MDT and in TGC. * Contains CMOS devices, bipolar devices, and optocouplers. * Foreseen radiation constraint in MDT barrel 1: 330 Gy - TID: 4.7 Gy x 3.5 x 5 x 4 = 330 Gy 33 krad in 10 years; - NIEL: 3.0E10 n/cm 2 x 5 x 1 x 4 = 6.0E11 n/cm 2 (1 MeV eq.) in 10years; - SEE: 5.4E9 h/cm 2 x 5 x 1 x 4 = 1.1E11 h/cm 2 (>20 MeV) in 10 years.

24 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 24 Quant ComponentTechn. TID (Gy) NIEL (n/cm 2 ) SEE Comments 1 ATMEGA103-6ACCMOS - - - NEW 1 AT90S2313-10SCCMOS~300 10 13 - If not programmed during irradiation 1 SAE81C91CMOS~300 10 13 - 1 PCA 82C250TBipolar~300 10 13 - 3 MIC5203-5.0BM4TSBipolar - - - NEW 1 MIC2754MBM5TSCMOS - - - NEW 1 ADP3607AR CMOS - - - NEW 2 HCPL-0601Opto - - - NEW 5 BAV70W diodeBipolar~300 10 13 - 4 BAT54W diodeBipolar - - - NEW 1 74HC1G66GWCMOS - - - NEW 1 CSTCC8.00MGQuartz - - - NEW 2 Quartz 32kHz SMDQuartz~300 10 13 - 1 CS5523-ASCMOS -- - NEW, better specs 16 MAX4582CEE CMOS -- - NEW, Analog Devices TID failed (75Gy) 1 AD680JRBipolar~300 10 13 - 1 MAX871EUK CMOS -- - NEW 1 NC74S14M5 PCMOS - - - NEW 1 74HC74ADT CMOS - - - NEW 4 NC7SZ00P5 CMOS - - - NEW 3 HCPL-0731Opto~300 >3 10 12 - Siemens NIELfailed at 3 10 11 n/cm 2 1 LMC6064 CMOSCMOS - - - NEW

25 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 25 Measurements on optocoulers

26 ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 26 Summary Status of H.W.  The printed circuit board of the ELMB has been tested and is ok! (Only fixation holes 1.6mm instead of 2.4mm)  20 pc is in production (15 Oct 2000)  Printed circuit board of the Motherboard is ready  20 prototypes will be available end of Oct 2000  Radiation tests are planned for February 2001  A first series of the ELMB will be produced to the Summer of 2001. Some components are on allocation!

Download ppt "ATLAS ATLAS DCS B.Hallgren, CERN EP/ ATD ATLAS DCS Workshop 2-3 Oct 2000 1 Hardware Status and Plans of the Embedded Local Monitor Board Hardware Status."

Similar presentations

SAAB SPACE 1 The M2 ASIC A mixed analogue/digital ASIC for acquisition and control in data handling systems Olle Martinsson AMICSA, October 2-3, 2006.

SAAB SPACE 1 The M2 ASIC A mixed analogue/digital ASIC for acquisition and control in data handling systems Olle Martinsson AMICSA, October 2-3, 2006.
ESODAC Study for a new ESO Detector Array Controller.

ESODAC Study for a new ESO Detector Array Controller.
DCS aspects of TDAQ racks in USA15 and SDX1 Y. Ermoline et al. ATLAS Week, CERN, 15 February 2005.

DCS aspects of TDAQ racks in USA15 and SDX1 Y. Ermoline et al. ATLAS Week, CERN, 15 February 2005.
Development of a Linux- based small-size controller using PoE technology T. Masuda, T. Fukui, R. Tanaka SPring-8 ICALEPCS2005, Oct. 10-14, Geneva, Switzerland.

Development of a Linux- based small-size controller using PoE technology T. Masuda, T. Fukui, R. Tanaka SPring-8 ICALEPCS2005, Oct , Geneva, Switzerland.
STARLight PDR 3 Oct ‘01I.1 Miller STARLight Control Module Design Ryan Miller STARLight Electrical Engineer (734) 763-5373

STARLight PDR 3 Oct ‘01I.1 Miller STARLight Control Module Design Ryan Miller STARLight Electrical Engineer (734)
FPIAA - Find Persons Inside Atlas Areas A system for finding and rescuing persons in a very large physics experiment Gianpaolo Benincasa, CERN-Geneva-Switzerland.

FPIAA - Find Persons Inside Atlas Areas A system for finding and rescuing persons in a very large physics experiment Gianpaolo Benincasa, CERN-Geneva-Switzerland.
Uli Schäfer Discussions with H.B. after last meeting… All ATLAS standard racks and crates will be monitored. Helfrieds group will equip them with ELMBs.

Uli Schäfer Discussions with H.B. after last meeting… All ATLAS standard racks and crates will be monitored. Helfrieds group will equip them with ELMBs.
DCS LEB Workshop ‘98, Rome, Detector Control System, H.J.Burckhart,1 Detector Control System H.J Burckhart, CERN u Motivation and Scope u Detector and.

DCS LEB Workshop ‘98, Rome, Detector Control System, H.J.Burckhart,1 Detector Control System H.J Burckhart, CERN u Motivation and Scope u Detector and.
Midterm Review 2006-04-11 1 MBS 2006 MP Electronics, Basic Concept  Two modules:  Probe module  Surface module  The surface module is replaced by the.

Midterm Review MBS 2006 MP Electronics, Basic Concept  Two modules:  Probe module  Surface module  The surface module is replaced by the.
Team Members Jordan Bennett Kyle Schultz Min Jae Lee Kevin Yeh.

Team Members Jordan Bennett Kyle Schultz Min Jae Lee Kevin Yeh.
ACES 2011 The third common ATLAS CMS Electronics Workshop for LHC upgrades March 9-11, 2011, CERN, Geneva, Switzerland Hardware:  ATMEL ATmega128 microcontroller.

ACES 2011 The third common ATLAS CMS Electronics Workshop for LHC upgrades March 9-11, 2011, CERN, Geneva, Switzerland Hardware:  ATMEL ATmega128 microcontroller.
Engineering 1040: Mechanisms & Electric Circuits Fall 2011 Introduction to Embedded Systems.

Engineering 1040: Mechanisms & Electric Circuits Fall 2011 Introduction to Embedded Systems.
Status of LAV FEE electronics G. Corradi, C. Paglia, D. Tagnani & M. Raggi, T. Spadaro, P. Valente.

Status of LAV FEE electronics G. Corradi, C. Paglia, D. Tagnani & M. Raggi, T. Spadaro, P. Valente.
Camera Interfacing using ARM7

Camera Interfacing using ARM7
David MacNair POWER SUPPLY 3/30/20061 Ethernet Power Supply Controller.

David MacNair POWER SUPPLY 3/30/20061 Ethernet Power Supply Controller.
Ivan Pogrebnyak Supervisors: Paramonov, Drake, Proudfoot ATLAS, MSU, Argonne Tile week upgrade session June 10, 2015 TileCal requirements for ELMB upgrade.

Ivan Pogrebnyak Supervisors: Paramonov, Drake, Proudfoot ATLAS, MSU, Argonne Tile week upgrade session June 10, 2015 TileCal requirements for ELMB upgrade.
EMBEDDED WEB SERVER. CONTENT: 1.ABSTRACT 2.INTRODUCTION TO EMBEDDED SYSTEMS 3.INTRODUCTION TO EMBEDDED WEB SERVER 4.BLOCK DIAGRAM 5.POER SUPPLY 6.COMPONENT.

EMBEDDED WEB SERVER. CONTENT: 1.ABSTRACT 2.INTRODUCTION TO EMBEDDED SYSTEMS 3.INTRODUCTION TO EMBEDDED WEB SERVER 4.BLOCK DIAGRAM 5.POER SUPPLY 6.COMPONENT.
Arctic Control Introduction V 1.0. Arctic Control The Arctic Control is a device with integrated wireless communications for controlling medium-voltage.

Arctic Control Introduction V 1.0. Arctic Control The Arctic Control is a device with integrated wireless communications for controlling medium-voltage.
Objectives How Microcontroller works

Objectives How Microcontroller works
1 Digital Voltage Transducer family DV from 1200 to 4200 V RMS DVL from 50 to 2000 V RMS.

1 Digital Voltage Transducer family DV from 1200 to 4200 V RMS DVL from 50 to 2000 V RMS.

Similar presentations

Ads by Google