2. Asbestos Awareness for Construction Activities ASBESTOS CANCER AND LUNG DISEASE HAZARD AUTHORIZED PERSONNEL ONLY RESPIRATORS AND PROTECTIVE CLOTHING ARE REQUIRED IN THIS AREA February 2009 DANGER

3. Course Objectives n Understand asbestos health hazards n Locate asbestos-containing materials n Recognize suspect asbestos materials n Identify asbestos releases n Understand procedures for reporting releases and possible asbestos exposure n Procedures for medical surveillance

4. What We’ll Cover n Health effects of asbestos n Common asbestos-containing materials n Good-faith inspections n Recognizing asbestos-containing materials n Proper response to disturbance of asbestos n Preventing exposures  Signs n Proper response for asbestos exposure  Medical surveillance

5. Forms of Asbestos n Naturally occurring mineral n 86 types, only six are regulated  Chrysotile  Amosite  Crocidolite  Tremolite  Actinolite  Anthophylite

6. Chrysotile n White asbestos n “Serpentine” n 95% of asbestos- containing products

7. Amosite n Brown asbestos n 4% of asbestos- containing products

8. Crocidolite n Blue asbestos n Less than 1% of asbestos-containing products

9. Other Forms n Tremolite n Anthophylite n Actinolite n Trace use only

10. Properties of Asbestos n Fire resistant n Chemical resistant n Is a good binder n Can be milled and woven

11. Asbestos Fibers n Occur in bundles n Bundles can break apart into fibers that can break into smaller and smaller fibers n Smallest fibers are so tiny the can only be seen with an electron microscope

12. Asbestos vs. Fiberglass

13. Historical Use n Pre 1930s  Long fibers - 10% of yield  Woven products - curtains, gaskets n Post 1930s  Shorter fibers  Added to roofing tar n Post 1950s  Expansion of industrial, commercial uses

15. Historical Exposure n Generally many times greater than today n No good health data on low dose exposure, so no dose considered safe n PEL =.1 fibers per cubic cm of air n Monitoring must be performed to determine exposure

16. High Exposure

17. Health Effects n Asbestos related diseases  Asbestosis  Lung Cancer  Mesothelioma n High exposure n No immediate symptoms n Delayed disease

18. Route of Exposure n Acute health effects n Inhalation  Asbestos must be airborne  Intact asbestos products do not pose a health risk

19. Asbestosis n Scarring of the lung n Not a cancer n Found with long term exposure n Difficult to breathe n No treatment

20. Lung Cancer n May be caused by other agents besides asbestos n Typically occurs because of long-term exposure n Smoking increases risk 50 to 90 times n Treatable with early detection

21. Kent Cigarette Filters

22. Mesothelioma n Cancer of the lining of the chest or abdominal cavity n Asbestos exposure only known cause n Can arise after limited, high-intensity exposure n Typically fatal within one year n Driver for regulating very low level exposures

23. Asbestos Deaths n According to CDC:  77 deaths from asbestosis in 1968  1,493 deaths from asbestosis in 2000  Overtook black lung deaths in 1998  Up to 40-year delay from exposure to illness  Asbestos-related disease expected to peak in 2010 Source: Lewiston Morning Tribune, 7/23/04

24. Asbestos n Friable asbestos (EPA)  can be reduced to powder by hand pressure when it is dry n Types  Thermal systems insulation (TSI)  Surface-applied materials  Popcorn ceilings (textural)  Sprayed-on fireproofing  L&I Class I Material (TSI & Surfacing)  L&I Class III Material (Includes TSI & Surfacing)  Maintenance and repair  Limited amounts of material may be removed

25. Miscellaneous Material n Non-friable n L&I Classes II and IV  Class II “Not TSI or Surfacing Material”  Floor tile and sheeting, mastics  Roofing and siding shingles  Asbestos-containing wallboard  Class IV custodians work on or around asbestos-containing materials without disturbing them (i.e., buffing floors)

26. Asbestos Classes (L&I) n Class I – Abatement requires certified companies and workers  TSI and surface-applied material n Class II – Abatement typically requires certified companies and workers  Resilient flooring, roofing, siding n Class III – Requires 16-hour training  Usually used in K-12 schools; maintenance work n Class IV – Requires 2-hour awareness training  For general maintenance and operation work  Shops, maintenance mechanics, custodians

27. Asbestos-Containing Materials n Pipe insulation n Duct insulation n Duct joint wrap n Boiler insulation n Floor tile, flooring felt n Linoleum n Drywall n Ceiling tiles n Popcorn ceilings n Transite siding n Asphalt roofing n Roofing felt, tar, paint n Caulk, putty, mastic n Joint & patch compounds

28. Other Asbestos-Containing Materials n Flexible connectors n Electrical wiring n Moisture barriers n Gaskets n Brakes/clutch pads n Chalkboards n Fire blankets n Fire doors n Spray on fire-proofing n Fume hood lining n Lab bench tops n Asbestos removal waste

29. Pipe Insulation

30. Fireproofing

31. Roofing

32. Floor Tile

33. Ceiling Tile SuspendedGlued-on

34. Pre-Construction n Before beginning a project in which building materials will be DISTURBED  Determine if asbestos is present (or presumed present)  Determine if asbestos (or presumed asbestos) will be disturbed  Abate asbestos (or presumed asbestos) before demolition

35. Locating Asbestos n A good faith inspection or survey is required for all construction/demolition work. Exceptions:  All construction materials are wood, glass or metal  If no asbestos disturbed, a “reasonable certainty” document n Copy of asbestos good faith inspection must be present at the work site n Identifies materials containing > 1% for EPA requirements n Identifies materials containing any detectable amounts of asbestos for employee protection purposes

36. Asbestos Abatement n Asbestos abated prior to any demolition in the work area n May be provisions for “discovered” asbestos-containing materials n All potentially exposed workers must be asbestos awareness trained  Training must be tailored to the specific work environment

37. Signs and Labels n Signs  Regulated areas n Labels  All products, including raw material, mixtures, scrap, waste, debris, and their containers

38. DANGER ASBESTOS CANCER AND LUNG DISEASE HAZARD AUTHORIZED PERSONNEL ONLY RESPIRATORS AND PROTECTIVE CLOTHING ARE REQUIRED IN THIS AREA

40. Regulated Areas n Signs immediately visible on all approaches n Monitoring outside regulated area for Class I and Class II n Barricade tape or other barriers optional n Good faith inspection available on site n Must be competent person on site (40-hr supervisor)

41. Discovered Material n Asbestos materials should be abated before construction project begins n What if you find some not previously identified?  Stop work immediately  Tell Construction Coordinator  Area must be isolated until cleared by sampling  Material evaluated  If asbestos, must be removed before continuing project

42. Identifying a Release n An asbestos release results in debris:  Visibly damaged asbestos-containing material  Dust or remnants of broken asbestos- containing material fallen on floors or on other surfaces

43. Recognize Damaged Asbestos n Torn insulation covering n Crumbling floor tile n Water-damaged or broken ceiling tiles n Damaged popcorn ceilings n Visible debris

44. Asbestos Debris n If you find asbestos debris:  Do not clean it up  Stay out of the area  Report it to your supervisor  Supervisors report asbestos debris to Construction Coordinator

45. Medical Surveillance n General Construction  Wear a respirator  Respiratory protection program  Physician exam dependent on questionairre n Asbestos exposure (anticipated or real)  30 days/year in asbestos work  30 days/year exposure above the PEL  Examination by physician

47. Summary n Asbestos is only dangerous if airborne n Asbestos in good condition is not harmful n Do not disturb asbestos n Obey warning signs and use protective measures n Report damaged asbestos or debris to your supervisor

48. Contents of L&I Standard n Descriptions, definitions, exposure limits n Regulated areas, compliance methods n Respiratory protection & PPE requirements n Hygiene facilities and practices n Hazard Communication n Employee information and training n Medical Surveillance n Competent person information n Appendices

49. Need More Information? n WSU Asbestos Management Program  http://www.ehs.wsu.edu/AMP/amphome.asp n WSU Asbestos Database  http://www.ehs.wsu.edu/asbestos/asbestos.htm n Environmental Health & Safety (EH&S)  Russ Schaff @ 335-5604 or schaffr@wsu.eduschaffr@wsu.edu  Dennis Sasse @ 335-5251 or dsasse@wsu.edu