Fresh Air Consulting Norman L. Morrow, Ph.D. November 5, 2003 MON Heat Exchanger Requirements.

Slides:

Advertisements

Similar presentations

Quality is a Lousy Idea-

Advertisements

MSW NESHAP Control Requirements Contains the same requirements as NSPS/EG. Requires gas collection and control system (GCCS) for same landfill as NSPS/EG.

METAL COIL SURFACE COATING MACT OVERVIEW 40 CFR PART 63, SUBPART SSSS May CFR PART 63, SUBPART SSSS May 2006.

METAL CAN SURFACE COATING MACT OVERVIEW 40 CFR PART 63, SUBPART KKKK June CFR PART 63, SUBPART KKKK June 2006.

METAL CAN SURFACE COATING MACT COMPLIANCE ASSURANCE 40 CFR PART 63, SUBPART KKKK June 2006 June CFR PART 63, SUBPART KKKK June 2006 June 2006.

METAL COIL SURFACE MACT COMPLIANCE ASSURANCE 40 CFR PART 63, SUBPART SSSS May 2006 May 2006.

START-UP AND OPERATION OF MECHANICALLY SEALED EQUIPMENT 1:13.

Fresh Air Consulting Norman L. Morrow, Ph.D. November 5, 2003 MON Equipment Leak Requirements.

Chapter Seven Compressible Fluid.

MON MACT Storage Tank & Transfer Racks Presenter: James Leonard November 5, 2003 ACC/SOCMA Conference New Orleans, LA.

CWAG 2010 WATER LAW CONFERENCE The Broadmoor Colorado Springs, Colorado April 29 – 30, 2010.

Fresh Air Consulting Norman L. Morrow, Ph.D. November 5, 2003 MON Continuous PV Requirements.

Tuesday Oct. 7, 2014 Implementation of Permit Exemption Criteria Category No. 38 Tom Corbett, Governor Dana Aunkst, Acting Secretary.

Discharge Monitoring Reports (DMRs)

Louisiana Department of EnvironmentalQuality LDEQ CAM Plan Overview LDEQ’s 27 th Annual Conference on the Environment Cajundome Convention Center Lafayette,

Outcome of Federal Actions on WA Water Quality Standards.

Implementation and Management of Leak Detection and Repair Programs – New Rules and Other Considerations Nebraska Ethanol Safety & Environmental Coalition.

Student Book © 2004 Propane Education & Research CouncilPage Performing Pressure Tests on Gas Distribution Lines Gas personnel must understand.

IAEA International Atomic Energy Agency Regulations Part II: Basic Concepts and Definitions Day 8 – Lecture 5(2)

Quality Control Testing

1 Improving the lives of 10 million older adults by 2020 © 2015 National Council on Aging The Low Income Home Energy Assistance Program (LIHEAP) 101 March.

Air Quality 101: Clean Air Act Overview/ Update. 2 Origins of the Clean Air Act Historic air pollution Donora, Pennsylvania, – PSD, tribes.

Natural Resource Concerns. In 2007 there were a number of food borne illness attributed to fresh produce People became sick Business’s lost market share.

1 Informal Document No. GRRF th GRRF,31 January – February 4, 2005 Agenda Item 5.9. Submission by the United States of America for information.

Clean Water Act (CWA) (1977, 1981, 1987). Description and Affects This Act was put into place in order to regulate the amount of pollutants that were.

Placing Vapor Distribution Systems and Appliances into Operation MODULE 8 System Tests.

Mississippi State Department of Health

Compliance Assurance and Title V Monitoring A Summary of the Rules and Applications Peter Westlin, EPA, OAQPS.

Quality WHAT IS QUALITY

EPA Overreach WATERS OF THE U S METHANE REDUCTION PLAN LEGISLATIVE /REGULATORY FORUM SEPTEMBER 16, 2015.

Delivering sustainable solutions in a more competitive world Benzene Waste Operations 40 CFR Part 61, Subpart FF SOCMI Wastewater 40 CFR Part 60, Subpart.

Hazard classification

1 Saxony-Anhalt EU Twinning RO 04/IB/EN/09 State Environmental Protection Agency Wolfgang GarcheWorkshop European Standards Requirements of.

Word Problems that Lead to Inequalities. Word Problem Solving Strategies Read through the entire problem. Highlight the important information and key.

Stability of FPPs- Conducting, Bracketing, Matrixing Sultan Ghani.

Report of the NPDES Subcommittee. Conference Call Meetings July 8 and August 19 Mercury Discharges – Utility Request to Address Permit Requirements for.

PVE Testing l Assurance that the OBD system is working properly in-use and meets the requirements of the regulation l Testing done close to the start of.

Point Source Loads and Decision Criteria for Toxics Modeling Baltimore Harbor TMDL Stakeholder Advisory Group September 10, 2002.

Revised Total Coliform Rule Sandy Brentlinger Southwest Drinking Water.

Confined and Concentrated Animal Feeding Permitting Indiana Soybean Alliance December 12, 2006.

Mine Emergency Preparedness Training Mine Recovery.

Changes to § Application of Standards and §307.9-Determination of Standards Attainment Gregg Easley Water Quality Standards Team Texas Commission.

Formaldehyde. Regulation v Regulated areas 1a Regulation v Signs and markings 1b.

1 Draft Landfill Methane Control Measure California Air Resources Board April 22, 2008.

NPDES Permitting for Coal Ash Ponds in North Carolina EMC Meeting January 12, 2012 Sergei Chernikov, Ph.D. 1.

What is Stormwater? Direct result of rainfall Recharges groundwater by infiltration Produces “runoff” (excess rainfall after infiltration) May be concentrated.

Quality is a Lousy Idea-

Total Coliform Rule (TCR)

Complying with Periodic Emissions Monitoring Requirements

Tyres PRI- Repak ELT Roadshow July 2017

Regulations Part II: Basic Concepts and Definitions

Concentration of free available residual chlorine

What you Will do if Your Car Transmission Fluid Leaking at Radiator.

TIPS TO MAINTAIN YOUR NEW AUDI CAR. THESE ARE THE THINGS TO BE TAKEN CARE TO AVOID DAMAGES FOR YOUR HEAVY INVESTMENT CAR, PEOPLE SEARCH MORE USED AUDI.

Quality is a Lousy Idea-

Clean Air Act (CAA) Purpose

What We’ll Cover What is the Low-Income Home Energy Assistance Program (LIHEAP)? Who does LIHEAP help? Overview of LIHEAP How LIHEAP Works Eligibility.

What it Means, Why it Works, and How to Comply

Unresolved Reg 2 Issues and Triennial Review Preview Raymond E

OHWARN Workshop Disruption of Service Rule Update

You and your lab partner independently determine the concentration of Ca2+ in a water sample. The results are: You Lab partner 350 ppm

Refrigeration Topics in this section:

Preparing for a Stack Test

Leaky Appliance Trigger Rate

Objectives Finalize AHU processes

Objectives Processes in Cooling towers and AHUs.

Meeting on reporting on Bathing Water Directive - 30/09/2008

Presentation transcript:

Fresh Air Consulting Norman L. Morrow, Ph.D. November 5, 2003 MON Heat Exchanger Requirements

Fresh Air Consulting Norman L. Morrow, Ph.D. November 5, 2003 What is a Heat Exchange System? Heat exchange system means any cooling tower system or once-through cooling water system (e.g., river or pond water). A heat exchange system can include more than one heat exchanger and can include an entire recirculating or once- through cooling system. [63.101]

Fresh Air Consulting Norman L. Morrow, Ph.D. November 5, 2003 What Heat Exchangers are Exempt? The heat exchange system operates with a minimum cooling water pressure at least 35 kPa (5.08 psi) greater than the maximum process side pressure. There is an intervening cooling fluid, containing <5 wt. % total HAP.

Fresh Air Consulting Norman L. Morrow, Ph.D. November 5, 2003 What Heat Exchangers are Exempt? (Cont’d) It’s a once-through system that is subject to a NPDES permit meeting specified conditions. It’s a once-through system used to cool fluids that contain <5 wt. % HON Table 9 HAP. It’s a recirculating system used to cool fluids that contain <5 wt. % HON Table 4 HAP.

Fresh Air Consulting Norman L. Morrow, Ph.D. November 5, 2003 Heat Exchange System Requirements Comply with the requirements of § of the HON. –Monitor each heat exchange system used to cool process equipment in an MCPU using the procedures in §63.104(b) or (c). –Whenever a leak is detected, comply with the requirements in §63.104(d).

Fresh Air Consulting Norman L. Morrow, Ph.D. November 5, 2003 What are the Monitoring Requirements? Monitor monthly for six months then quarterly. Monitor individual heat exchangers or groups. Take triplicate samples and use EPA approved methods or monitor surrogates following a monitoring plan.

Fresh Air Consulting Norman L. Morrow, Ph.D. November 5, 2003 What is a leak? Using EPA methods: –A leak is detected if the exit mean concentration is greater than the entrance mean concentration using a one-sided statistical procedure at 0.05 level of significance and the amount by which it is greater is at least 1 ppm or 10% of the entrance mean, whichever is greater.

Fresh Air Consulting Norman L. Morrow, Ph.D. November 5, 2003 What is a leak? Using a surrogate: –The leak detection criteria is specified and justified in the monitoring plan.

Fresh Air Consulting Norman L. Morrow, Ph.D. November 5, 2003 Repair Provisions If a leak is detected, repair as soon as practical, but not later than 45 days after receiving the monitoring results. Remonitoring after repair is required. Delay of repair is allowed under certain, limited situations.