1. Basic Suturing Workshop

2. Objectives Describe the principles of wound healing
Identify the various types and sizes of suture material.
Choose the proper instruments for suturing.
Identify the different injectable anesthetic agents and correct dosages.
Demonstrate different types of closure techniques: simple interrupted, continuous, subcuticular, vertical and horizontal mattress, dermal
Demonstrate two-handed, one-handed, instrument ties
Recommend appropriate wound care and follow-up.

3. Critical Wound Healing Period
Tissue
Skin
Mucosa
Subcutaneous
Peritoneum
Fascia
5-7 days
5-7 days
7-14 days
7-14 days
14-28 days
Tissue Healing Time/Days

4. Model of Wound Healing
(1) Hemostasis: within minutes post-injury, platelets aggregate at the injury site to form a fibrin clot.
(2) Inflammatory: bacteria and debris are phagocytosed and removed, and factors are released that cause the migration and division of cells involved in the proliferative phase.
(3) Proliferative: angiogenesis, collagen deposition, granulation tissue formation, epithelialization, and wound contraction
(4) Remodeling: collagen is remodeled and realigned along tension lines and cells that are no longer needed are removed by apoptosis.
Phases are sequential, yet overlap

5. Surgical Principles Incision Dissection Tissue handling Hemostasis
Moisture/site
Remove infected, foreign, dead areas
Length of time open
Choice of closure material/mechanism
Primary or secondary
Cellular responses
Eliminate dead space
Closing tension
Distraction forces and immobilization/care

6. Suture Materials Criteria Tensile strength Good knot security
Workability in handling
Low tissue reactivity
Ability to resist bacterial infection

7. Types of Sutures Absorbable or non-absorbable (natural or synthetic)
Monofilament or multifilament (braided)
Dyed or undyed
Sizes 3 to 12-0 (numbers alone indicate progressively larger sutures, whereas numbers followed by 0 indicate progressively smaller)
New antibacterial sutures

8. Non-absorbable Absorbable Not biodegradable and permanent Nylon
Prolene
Stainless steel
Silk (natural, can break down over years)
Degraded via inflammatory response
Vicryl
Monocryl
PDS
Chromic
Cat gut (natural)
Nylon (Ethilon®): of all the non-absorbable suture materials, monofilament nylon is the most commonly used in surface closures.
 Polypropylene (Prolene®): appears to be stronger then nylon and has better overall wound security.
BRAIDED: includes cotton, silk, braided nylon and multifilament dacron. Before the advent of synthetic fibers, silk was the mainstay of wound closure. It is the most workable and has excellent knot security. Disadvantages: high reactivity and infection due to the absorption of body fluids by the braided fibers.

9. Natural Suture Synthetic Synthetic polymers Biological
Do not cause inflammatory response
Nylon
Vicryl
Monocryl
PDS
Prolene
Biological
Cause inflammatory reaction
Catgut (connective from cow or sheep)
Silk (from silkworm fibers)
Chromic catgut

10. Multifilament (braided)
Monofilament
Multifilament (braided)
Single strand of suture material
Minimal tissue trauma
Smooth tying but more knots needed
Harder to handle due to memory
Examples: nylon, monocryl, prolene, PDS
Fibers are braided or twisted together
More tissue resistance
Easier to handle
Fewer knots needed
Examples: vicryl, silk, chromic

11. Suture Materials

12. Suture Selection Do not use dyed sutures on the skin
Use monofilament on the skin as multifilament harbor BACTERIA
Non-absorbable cause less scarring but must be removed
Plus sutures (staph, monocryl for E. coli, Klebsiella)
Location and layer, patient factors, strength, healing, site and availability

13. Suture Selection Absorbable for GI, urinary or biliary
Non-absorbable or extended for up to 6 mos for skin, tendons, fascia
Cosmetics = monofilament or subcuticular
Ligatures usually absorbable

14. Suture Sizes

15. Surgical Needles Wide variety with different company’s naming systems
2 basic configurations for curved needles
Cutting: cutting edge can cut through tough tissue, such as skin
Tapered: no cutting edge. For softer tissue inside the body

16. Surgical Needles

17. Surgical Instruments
Tissue Forceps, Dressing Forceps, Needle Holder (Driver), Iris scissors (debridement/revision), Dissection Scissors (heavier tissue revision, wound undermining), Hemostats (clamping blood vessels, grasping,exploring), Suture Removal Scissors

18. Scalpel Blades

19. Anesthetic Solutions Lidocaine (Xylocaine®) with epinephrine
Vasoconstriction
Decreased bleeding
Prolongs duration
Strength: 0.5% & 1.0%
Maximum individual dose:
7mg/kg, or
500mg
Lidocaine (Xylocaine®)
Most commonly used
Rapid onset
Strength: 0.5%, 1.0%, & 2.0%
Maximum dose:
5 mg / kg, or
300 mg
1.0% lidocaine = 1 g lidocaine / 100 cc = 1,000mg/100cc
300 mg = 0.03 liter = 30 ml

20. Anesthetic Solutions
CAUTIONS: due to its vasoconstriction properties never use Lidocaine with epinephrine on:
Eyes, Ears, Nose
Fingers, Toes
Penis, Scrotum

21. Anesthetic Solutions BUPIVACAINE (MARCAINE): Slow onset Long duration
Strength: 0.25%
DOSE: maximum individual dose 3mg/kg

22. Local Anesthetics

23. Injection Techniques 25, 27, or 30-gauge needle 6 or 10 cc syringe
Check for allergies
Insert the needle at the inner wound edge
Aspirate
Inject agent into tissue SLOWLY 
Wait…
After anesthesia has taken effect, suturing may begin

24. Wound Evaluation Time of incident Size of wound Depth of wound
Tendon / nerve involvement
Bleeding at site

25. When to Refer
Deep wounds of hands or feet, or unknown depth of penetration
Full thickness lacerations of eyelids, lips or ears
Injuries involving nerves, larger arteries, bones, joints or tendons
Crush injuries
Markedly contaminated wounds requiring drainage
Concern about cosmesis

26. Contraindications to Suturing
Redness
Edema of the wound margins
Infection
Fever
Puncture wounds
Animal bites
Tendon, nerve, or vessel involvement
Wound more than 12 hours old (body) and 24 hrs (face)

27. Closure Types Primary closure (primary intention)
Wound edges are brought together so that they are adjacent to each other (re-approximated)
Examples: well-repaired lacerations, well reduced bone fractures, healing after flap surgery
Secondary closure (secondary intention)
Wound is left open and closes naturally (granulation)
Examples: gingivectomy, gingivoplasty,tooth extraction sockets, poorly reduced fractures
Tertiary closure (delayed primary closure)
Wound is left open for a number of days and then closed if it is found to be clean
Examples: healing of wounds by use of tissue grafts.

28. Wound Preparation
Most important step for reducing the risk of wound infection.
Remove all contaminants and devitalized tissue before wound closure.
IRRIGATE w/ NS or TAP WATER (AVOID H2O2, POVIDONE-IODINE)
CUT OUT DEAD, FRAGMENTED TISSUE
If not, the risk of infection and of a cosmetically poor scar are greatly increased
Personal Precautions

29. Basic Laceration Repair
Principles And Techniques

30. Langer’s Lines
The general course of bundles of connective tissue within the dermis. Wounds that cross these lines tend to be widened by the inherent tension.

31. Principles And Techniques
Minimize trauma in skin handling
Gentle apposition with slight eversion of wound edges
Visualize an Erlenmeyer flask
Make yourself comfortable
Adjust the chair and the light
Change the laceration
Debride crushed tissue

32. Types of Closures
Simple interrupted closure – most commonly used, good for shallow wounds without edge tension
Continuous closure (running sutures) – good for hemostasis (scalp wounds) and long wounds with minimal tension
Locking continuous - useful in wounds under moderate tension or in those requiring additional hemostasis because of oozing from the skin edges
Subcuticular – good for cosmetic results
Vertical mattress – useful in maximizing wound eversion, reducing dead space, and minimizing tension across the wound
Horizontal mattress – good for fragile skin and high tension wounds
Percutaneous (deep) closure – good to close dead space and decrease wound tension

33. Simple Interrupted Suturing
Apply the needle to the needle driver
Clasp needle 1/2 to 2/3 back from tip
Rule of halves:
Matches wound edges better; avoids dog ears
Vary from rule when too much tension across wound

34. Simple Interrupted Suturing
Rule of halves 1

35. Simple Interrupted Suturing
Rule of halves 3 1 1 2

36. Suturing
The needle enters the skin with a 1/4-inch bite from the wound edge at 90 degrees
Visualize Erlenmeyer flask
Evert wound edges
Because scars contract over time

37. Suturing
Release the needle from the needle driver, reach into the wound and grasp the needle with the needle driver. Pull it free to give enough suture material to enter the opposite side of the wound.
Use the forceps and lightly grasp the skin edge and arc the needle through the opposite edge inside the wound edge taking equal bites.
Rotate your wrist to follow the arc of the needle.
Principle: minimize trauma to the skin, and don’t bend the needle. Follow the path of least resistance.

38. Suturing
Release the needle and grasp the portion of the needle protruding from the skin with the needle driver. Pull the needle through the skin until you have approximately 1 to 1/2-inch suture strand protruding form the bites site.
Release the needle from the needle driver and wrap the suture around the needle driver two times.

40. Simple Interrupted Suturing
Grasp the end of the suture material with the needle driver and pull the two lines across the wound site in opposite direction (this is one throw).
Do not position the knot directly over the wound edge.
Repeat 3-4 throws to ensuring knot security. On each throw reverse the order of wrap.
Cut the ends of the suture 1/4-inch from the knot.
The remaining sutures are inserted in the same manner

41. Simple, Interrupted

42. The trick to an instrument tie
Always place the suture holder parallel to the wound’s direction.
Hold the longer side of the suture (with the needle) and wrap OVER the suture holder.
With each tie, move your suture-holding hand to the OTHER side.
By always wrapping OVER and moving the hand to the OTHER side = square knots!!

43. Two Handed Tie

44. Two Handed Tie

45. Continuous Locking and Nonlocking Sutures

47. Suturing - finishing
After sutures placed, clean the site with normal saline.
Apply a small amount of Bacitracin or white petroleum and cover with a sterile non-adherent compression dressing (Tefla).

48. Suturing - before you go…
Need for tetanus globulin and/or vaccine?
Dirty (playground nail) vs clean (kitchen knife)
Immunization history (>10 yrs need booster or >5 yrs if contaminated)
Tell pt to return in one day for recheck, for signs of infection (redness, heat, pain, puss, etc), inadequate analgesia, or suture complications (suture strangulation or knot failure with possible wound dehiscence)
It should be emphasized to patients that they return at the appropriate time for suture removal or complications may arise leading to further scarring or subsequent surgical removal of buried sutures.

49. Patient instructions and follow up care
Wound care
After the first hours, patients should gently wash the wound with soap and water, dry it carefully, apply topical antibiotic ointment, and replace the dressing/bandages.
Facial wounds generally only need topical antibiotic ointment without bandaging.
Eschar or scab formation should be avoided.
Sunscreen spf 30 should be applied to the wound to prevent subsequent hyperpigmentation.

50. Suture Removal Average time frame is 7 – 10 days
FACE: 3 – 5 d
NECK: 5 – 7 d
SCALP: 7 – 12 days
UPPER EXTREMITY, TRUNK: 10 – 14 days
LOWER EXTREMITY: 14 – 28 days
SOLES, PALMS, BACK OR OVER JOINTS: 10 days
Any suture with pus or signs of infections should be removed immediately.

51. Suture Removal
Clean with hydrogen peroxide to remove any crusting or dried blood
Using the tweezers, grasp the knot and snip the suture below the knot, close to the skin
Pull the suture line through the tissue- in the direction that keeps the wound closed - and place on a 4x4. Count them.
Most wounds have < 15% of final wound strength after 2 wks, so steri-strips should be applied afterwards.

52. Topical Adhesives
Indications: selection of approximated, superficial, clean wounds especially face, torso, limbs. May be used in conjunction with deep sutures
Benefits: Cosmetic, seals out bacteria, apply in 3 min, holds 7 days (5-10 to slough), seal moisture, faster, clear, convenient, less supplies, no removal, less expensive
Contraindicated with infection, gangrene, mucosal, damp or hairy areas, allergy to formaldehyde or cryanoacrylate, or high tension areas

53. Dermabond® A sterile, liquid topical skin adhesive
Reacts with moisture on skin surface to form a strong, flexible bond
Only for easily approximated skin edges of wounds
punctures from minimally invasive surgery
simple, thoroughly cleansed, lacerations

54. Dermabond® Standard surgical wound prep and dry
Crack ampule or applicator tip up; invert
Hold skin edges approximated horizontally
Gently and evenly apply at least two thin layers on the surface of the edges with a brushing motion with at least 30 s between each layer, hold for 60 s after last layer until not tacky
Apply dressing

55. Follow Up Care with Adhesives
No ointments or medications on dressing
May shower but no swimming or scrubbing
Sloughs naturally in 5-10 days, but if need to remove use acetone or petroleum jelly to peel but not pull apart skin edges
Pt education and documentation

56. References
Thomsen, T. Basic Laceration Repair. The New England Journal of Medicine. Oct. 355: 17.
Edgerton, M. The Art of Surgical Technique. Baltimore, Williams & Wilkins, 1988.
2009, topic lacerations, etc.
Jackson, E. Wound Care – Suture, Laceration, Dressing: Essentials for Family Physicians. AAFP Scientific Assembly