1. TRITEX BLEACHING SYSTEM FOR CELLULOSIC FIBERS AND BLENDS

2. TRITEX BLEACHING SYSTEM
Reduced water and energy consumption
Short Process time
Safe dyeing
High reproducibility

3. TRITEX BLEACHING PROCESS
0.4 g/l Triscour Jet Conc
0.2 g/l Trilube BW liq
0.1 g/l Tristabilizer Jet g/l NaOH 50%
6.0 g/l H2O2 35%
Neutralisation
1.0 ml/l Triassist DSA
H2O2 elimination
0.1 ml/l Triminox GH
50C
100C
4.0C/min
15 min
80C
-3.0C/min
dyeing
110C
30 min
Total Process time:
75 Min
Liquor Ratio
6:1
Rinsing bath: 1

4. TRISCOUR JET CONC 100% active detergent developed especially
to provide the following properties:
Excellent degree of whiteness
Outstanding hydrophilicity and very good absorbancy
Low foam product suitable for all kinds of machines
Stable to high pH and electrolytes
Very efficient for cleaning cotton/elastane blends
Suitable for PDF and Full white

5. TRISCOUR JET CONC Hydrophilicity after discontinuous peroxyde Bleach
Competition
Rewetting 8 sec
Triscour Jet Conc
Instant Rewetting
Removal of oils and grease efficiency
Competition
Poor detergency
Triscour Jet-4
No redeposition

6. TRISCOUR JET CONC
The graph illustrates that Triscour Jet CONC results in a superior white

7. Limit for Jet application
TRISCOUR JET CONC
Limit for Jet application
Foam level (mm)

8. When the thread sags thetime is stopped
Draves Test
0 Seconds
Triscour Jet CONC
15 Seconds
Competition
0 Seconds
45 Seconds
Bleached Yarn
When the thread sags thetime is stopped
Thread and weight
This demonstrates that the speed of wetting of 100% bleached cotton with Triscour JET CONC is faster than the competition
The Draves Test:
100% cotton yarn is bleached with the products to be evaluated and then dried. The yarn is attached to a weight by the use of thread and then dropped into a cylinder filled with water. From the time the weight is at the bottom of the cylinder to the time the tread attached to the yarn and the weight sags is recorded as the wetting speed.

9. TRIASSIST DSA Removes residual alkali from bleaching
Core neutralisation of the fabric
Excellent dispersing properties and prevent deposits on fabric and machinery
Good binding properties with Fe, Ca and Mg
No formation of undesired salts or buffers during neutralisation

10. TRIMINOX GH Works over a very broad range of pH from 3 to 10
Efficient in a wide temperature spectrum up to 65C

11. THANK YOU!