1. FHM TRAINING TOOLS This training presentation is part of FHM’s commitment to creating and keeping safe workplaces. Be sure to check out all the training programs that are specific to your industry.

2. Temporary Heaters Propane Safety

3. Temporary Heaters Circulating air type heater: – maintain 12” clearance on both sides & rear

4. Temporary Heaters At least 10’ from tarps, canvas or similar coverings Set level on non- combustible surface

5. Temporary Heaters Locate heater at least 6’ from LPG bottle Heater blower not directed toward bottle within 20’

6. Temporary Heaters LPG containers shall sit on level substantial surface Tie cylinder in upright position if necessary

7. Temporary Heaters Supply fresh air Use fans if necessary

8. Temporary Heaters

9. Propane & Temp Heaters Frost on tank means – drawing too much vapor – reduced fuel flow Don’t lay cylinder on side Don’t change regulator setting to increase fuel flow

10. Temporary Heaters Carbon Monoxide – odor/colorless – 55 PPM max. exposure* Carbon Dioxide – odor/colorless – 5,000 PPM

11. Propane For every 100,000 BTUs, use one 100 lb. tank Separate heaters by 20’ Max. 3 bottles (300 lbs.) per heater

12. Propane Manifolds – don’t use copper, they leak! – Use only LPG or LP- Gas rated rubber hoses – No auto-type hose clamps – Test connections for leaks

13. Propane Cylinder connectors should have flame- loss device to shut- off fuel if pilot light or flame goes out

14. Propane TANKS – valve-end up while in use – place away from heaters, electrical panels, slag, flames, etc.

15. Propane Don’t take into confined spaces Gas is heavier than air Expands at 1:270 ratio – displaces oxygen

16. Propane Do not store inside buildings or “gangboxes”

17. Propane Protect tanks from damage

18. Propane At least one, 20-B:C fire extinguisher per storage area 501 lbs.>, 10’ from building*

19. Propane 1,000 OR > pounds = – DOT placards – Bill of Lading – CDL, 21 years old, speak & read English

20. Natural Gas Flex hose not to exceed 25’ Leak test all connections All connections have pull strength of 400 lb. Flame-loss device