Presentation is loading. Please wait.

Presentation is loading. Please wait.

Fire Science Program Dutchess Community College Poughkeepsie, NY TGI (Wooden I beam) Test Burn April 4, 2009 Dutchess Community College Fire Science program.

Similar presentations


Presentation on theme: "Fire Science Program Dutchess Community College Poughkeepsie, NY TGI (Wooden I beam) Test Burn April 4, 2009 Dutchess Community College Fire Science program."— Presentation transcript:

1 Fire Science Program Dutchess Community College Poughkeepsie, NY TGI (Wooden I beam) Test Burn April 4, 2009 Dutchess Community College Fire Science program 2

2 Wooden I Beams Large surface area with little mass. 2 Wood “beams” with OSB acting as web member (TGI) OSB-Oriented Stand Board web- Many small pieces of wood held together by combustible glue. Strong until subjected to high heat. Dutchess Community College Fire Science program

3 OUR TESTS STATS Four 16’ TGI’s, ½ “Plywood roof Supported by two 6 high 2x4 walls with fire side covered by sheetrock. – Joints not taped – Nails not spackled over Fireload- hay, pallets, 1 couch, 1 stuffed chair, 1 dresser Weight on roof- approximately 300 lbs (water in plastic barrel) Dutchess Community College Fire Science program

4

5

6 Side B Dutchess Community College Fire Science program

7 Side D Dutchess Community College Fire Science program

8

9 Some of the DCC Fire Science students Left-right: Scott Steinebach, Patrick Rose, Erik Swingle Brendan Nugent, Tyler Carlson, Preston Kinzel, Doug Palmesi, Tim Conboy, Sarah Baker, Dominic Boscardin. Dutchess Community College Fire Science program

10

11 1 min. after ignition

12 Dutchess Community College Fire Science program 2 mins after ignition

13 Dutchess Community College Fire Science program 3 mins after ignition

14 Dutchess Community College Fire Science program 4 mins. After ignition Drum is falling through- roof is failing.

15 Dutchess Community College Fire Science program Center two TGI’s have failed (where weight was) and little is left of remaining 2 TGI’s

16 Dutchess Community College Fire Science program

17

18

19 Note-sheetrock held back fire. Note where fire came through joints that hadn’t been taped and spackled. Dutchess Community College Fire Science program

20

21 After sheetrock was removed, nail was easily removed from wood as heat had conducted to the wood via the nail and pyrolytic decomposition started on the wood, loosening its grip on the nail. Note-nail head had not be spackled over. Dutchess Community College Fire Science program

22 Top of 2x4” stud where fire lapped over sheetrock on the wall Dutchess Community College Fire Science program

23 Char on unprotected wood stud from wall Dutchess Community College Fire Science program

24 Compare the mass; wood beam vs TGI/wooden I beam Dutchess Community College Fire Science program

25 Test Burn Observations TGI’s burn quickly High surface area coupled with little mass cause early failure Without weight on them, they can appear to remain in place even with substantial burn time. Application of any weight will cause immediate failure. ** Cases have been reported of carpet holding remnants of I beam in place. Unsuspecting firefighters who fail to continually test floor ahead of them immediately fall through. Dutchess Community College Fire Science program

26 TEST NOTES This was not a scientific test, just a “let’s see what happens” event. TGI’s were not protected by sheetrock which they likely would in “real world”, but………. Fireload was: – Less than normal (hay and wood pallets possess 1/3 BTU energy of today’s synthetic fireload. – Fire area was wide open; heat could readily vent out (escape) – Weight (water barrel) was able to fall through when center 2 TGI‘s failed, thus catastrophic floor collapse did not occur. If weight had been distributed, undoubtedly floor would have catastrophically failed, without warning. Dutchess Community College Fire Science program

27 Our Thanks Go To: Williams Lumber, Rhinebeck, NY Dutchess County Department of Emergency Response, Poughkeepsie, NY Rhinebeck FD Pleasant Valley FD Dutchess Community College Fire Science program

28 Beware of Lightweight Construction Wooden I beams (TGI’s Trusses Never operate above or below any truss or wooden I beam (TGI) that is being exposed to heat from a fire Dutchess Community College Fire Science program

29 The End-Be Safe Expect the Unexpected Dutchess Community College Fire Science program


Download ppt "Fire Science Program Dutchess Community College Poughkeepsie, NY TGI (Wooden I beam) Test Burn April 4, 2009 Dutchess Community College Fire Science program."

Similar presentations


Ads by Google