Presentation on theme: "LTI’s 2014 Summary LTI NO. DATE Company INJURY DIR"— Presentation transcript:
1 LTI’s 2014 Summary LTI NO. DATE Company INJURY DIR 01/01/2014Sea and LandHand fractureUWDLTI#1526/03/2014OFSATmultiple fractures to both his legsLTI#0209/01/2014Saxon EnergyGroinLTI#1631/03/2014Abraj Energyfracture right leg and injuries left hand.OSDLTI#0318/01/2014Dalma Energylacerated handLTI#1730/03/2014MB Petroleum ServicesLeft wrist FractureLTI#0424/01/2014Shiv-VaniFatality head injuryLTI#1802/04/2014Dalma Energy Rig 47fracture of left wrist and forearm.LTI#0525/01/2014Desert Byrne DrillingFractured collarbone and dislocated left shoulderLTI#1906/04/2014Dalma Energy Rig 58fracture of right lower leg.LTI#0604/03/2014Arabian Industries ProjectsRib FractureLTI#20Wood Group cccfracture of distal phalanx right index fingerLTI#0722/01/2014Shaleem PetroleumFractured ankleLTI#2126/04/2014WeatherfordFracture of left legLTI#0822/02/2014VanguardMultiple foot fractureLTI#2207/05/2014Al BunyaanAmputation & fracture of three fingersONDLTI#0926/02/2014Al TurkiMultiple fracturesUIDLTI#10MidwescoFoot fractureLTI#1125/02/2014Bahwan ExcelMiddle Finger FractureLTI#1213/03/2014Cactus Premier Drillingfracture and dislocation of the right elbow jointLTI#13Oman Oil Marketingfracture of L1 vertebra and canal compromiseLTI # 1423/03/2014SOSchemical eye injuriesFor enquiries and or comments on these slides, please Contact; Sami AlHarthy on
2 Accident Location: Sea and Land in West-19, Burhan Back to Main PageLTI NotificationLTINo 0120141thJanuaryAccident Location: Sea and Land in West-19, BurhanWHAT HAPPENED:The IP was holding onto a lifting sub for a 6 ½” drill collar to guide it whilst it was being lifted from its basket by the off driller side air winch. During the lift the IP lost his grip on the lifting sub, it slipped from his hand and swung towards the mast leg. The IP attempted to stop it striking the leg and in doing so his left hand was crushed between the lifting sub and the leg. The IP was taken to the rig clinic for initial treatment and then transferred first to Adam Hospital and then later to Nizwa Hospital where he was diagnosed as having fractured his left hand.INJURY:Hand fracture .6 weeks off work .Position of hand shown by glove when trapped against rig mast
3 Accident Location: Saxon Energy, Marmul Back to Main PageLTI NotificationLTINo 0220149thJanuaryAccident Location: Saxon Energy, MarmulWHAT HAPPENED:The IP was on the rig floor completing the nippling down of the blow-out preventer. After laying down the mousehole, the crew had placed a an ill-fitting temporary cover over it. The IP stepped on the temporary cover which moved causing him to slip, fall over and sustain an injury to his groin area.First aid was administered by the rig medic and the injured man was sent directly to Salalah hospital for further treatment on a deep laceration.INJURY:Groin.5 weeks off work .Х√
4 Accident Location: Dalma Energy, Nimr Back to Main PageLTI NotificationLTINo 03201418thJanuaryAccident Location: Dalma Energy, NimrWHAT HAPPENED:The floor man (IP) & driller were inside the cellar nippling up the Tubing Head Spool (THS) onto the Casing Head Housing assembly (CHH). Whilst attempting to align one of the bolts on the THS into the corresponding hole of the CHH assembly, the IP placed his left hand inside the gap between the THS and CHH assembly. When the bolt had aligned the THS dropped down onto the CHH and trapped IP’s left hand in between the two flanges.The IP was immediately sent to the PDO Nimr clinic. First aid was given and then he was transferred to the Salalah Hospital for further treatment. He was diagnosed with a deep cut wound at palmer side of the hand.lacerated hand,INJURY:lacerated hand.2 weeks off work .Pinch point
5 Back to Main PageLTI NotificationLTINo 04201424thJanuaryAccident Location: Salalah to Muscat road, Fatal motor vehicle incidentA fatal motor vehicle incident occurred on the Salalah to Muscat road on Friday, 24 January, 2014 at approximately 15:45 hrs. The deceased was a 41-year-old Pakistani truck driver working for Ajib Trading LLC, a sub-contractor to our hoist contractor Shiv-vani. WHAT HAPPENED:The truck was transporting drill pipes from Shiv-vani’s hoist-21, operating in Saih Nihayda, to the Sino Gulf base in Nizwa. En route the truck rolled over, which sadly resulted in the driver losing his life. An investigation into the incident is underway.Our thoughts and prayers are with the family, friends and colleagues of the deceased.
6 LTI Notification No 06 LTI 04th March 2014 Back to Main PageLTI NotificationLTINo 06201404thMarchAccident Location: Al Noor MGI Phase 3A project ,Arabian Industries Projects,NimrWHAT HAPPENED:The IP and an operator were working at height inside the bucket of a bucket truck. They were in the process of cutting temporary wooden supports from a pipe rack and had just moved the bucket into position beneath one of the wooden supports. While attempting to position themselves within the bucket to cut the support, the controls of the bucket were accidently engaged. The bucket moved trapping the rigger between the guard rail of the bucket and the pipe rack structure. The operator reacted quickly and managed to drop the basket both backwards and downwards to save further injury. The PTW Holder who was at location raised the alarm and an ambulance arrived to evacuate the IP to the construction camp clinic. He was later referred on to the PDO Marmul clinic and then on to the Salalah Hospital where he was diagnosed as having fractured his ribs.INJURY:IP having ribs fracture
7 Accident Location: Desert Byrne Drilling, Lekhwair Back to Main PageLTI NotificationLTINo 05201425thJanuaryAccident Location: Desert Byrne Drilling, LekhwairWHAT HAPPENED:During a rig move the truck was transporting a diesel tank secured on a flat bed trailer from Lekhwair to Yibal. Whilst negotiating a sharp right hand bend he lost control causing the truck and trailer to roll over. Both the driver and his passenger were initially taken to the Yibal PDO clinic for their initial treatment and then transferred to Nizwa hospital for further examination and treatment where the driver was diagnosed with a fractured collar bone and dislocated left shoulder joint. The passenger suffered only minor bruises and was discharged with painkillers.Bend the lorry was negotiatingINJURY:Fractured collar bone and dislocated left shoulder.3 weeks off work .
8 Accident Location: Hoist 25 Nimr , Shaleem Petroleum Back to Main PageLTI NotificationLTINo 07201422ndJanuaryAccident Location: Hoist 25 Nimr , Shaleem PetroleumWHAT HAPPENED:The IP was re-arranging a sewage pipe over the edge of the waste pit when he lost his balance and fell 1.5m down the slope into the pit and in doing so twisted his right ankle. At 18:30 pm he informed the HSE Advisor from the camp site who took him to the Sahara PAC Clinic where he received an injection and painkiller. On the 26th January the pain had not subsided and so we was referred to the Badr Al Sama Hospital in Salalah for a specialist X-ray which revealed a fracture in the right ankle.INJURY:Fractured right ankle.6 weeks off work .IP bending to move pipe lost balance and slipped into waste pit
9 Accident Location: Thulailat-151 well in the Marmul area, Vanguard Back to Main PageLTI NotificationLTINo 08201422ndFebruaryAccident Location: Thulailat-151 well in the Marmul area, VanguardWHAT HAPPENED:The incident occurred during the wireline logging operation. While the wireline operator was pulling the cable out of the hole, the IP climbed on the deck of the unit to clean the winch area. After cleaning one side, he attempted to cross to the other side between two wire drums. His foot became trapped and was crushed between the moving wire drum and a steel frame. The operator immediately stopped the winch and reversed it to free the IP’s foot.The IP was immediately taken to the Marmul PDO clinic for his initial treatment and then transferred to Salalah hospital where he was diagnosed as suffering from multiple fractures of his right foot. He was later referred onto Khoula hospital, Muscat for re-constructive surgery.IP’s foot was hereINJURY:Multiple fractures of his right foot.8 weeks off work .
10 Accident Location: Ras Al Hamra project in Muscat, Al Turki Back to Main PageLTI NotificationLTINo 09201426thFebruaryAccident Location: Ras Al Hamra project in Muscat, Al TurkiWHAT HAPPENED:The IP was working on a balcony situated at roof height on one of the new director houses. Employees were protected from a fall from height by barrier protection which had been fitted at the edge of the balcony. The IP lent against the barrier which gave way and he and the barrier fell 10 metres down to the ground below. He was immediately given first aid and then transferred to Khoula hospital where he was admitted to intensive care. He sustained multiple fractures. INJURY:IP sustained multiple fractures admitted to intensive careIP fell from 2nd floor balcony IP landed on ground floor
11 Accident Location: Fahud, Midwesco workshop, Midwesco Back to Main PageLTI NotificationLTINo 10201426thFebruaryAccident Location: Fahud, Midwesco workshop, MidwescoWHAT HAPPENED:A chief mechanic and a mechanic were removing a 18kg pin from a cross head and connecting rod for a JWS-400 pump using a press. As the chief mechanic (IP) operated the press which pushed the pin vertically down out of the hole the other mechanic crouched down and waited to catch the pin when it emerged fully from the hole. Unfortunately as the pin was greasy, as it came out he lost his grip on it and it fell 30cm down onto the left foot of the IP who was still operating the press. The crew administered first aid and then he was transferred to the Fahud PDO Clinic. He was then referred onto Ibri hospital where he was diagnosed as suffering from a fracture to his foot. INJURY:IP suffering from a fracture to his foot.
12 LTI Notification No 11 LTI 25th February 2014 INJURY: Back to Main PageLTI NotificationLTINo 11201425thFebruaryAccident Location: Al Mukhtar, a subcontractor of the 4PL logistics contractor for PDOWHAT HAPPENED:The driver arrived at Rig 7’s new location with a full load of pipes and casing joints. After he had unstrapped the load, the Truckoman rig moving crew began to unload it using a forklift truck. Whilst the unloading was taking place the driver at the back of the trailer attempted to remove wooden dunnage which separates different levels of the load and allows the forks of the forklift to slide under the piping. In the process of removing the dunnage he caused a pipe to roll which trapped his hand between the pipe and a trailer support stanchion. He managed to remove his hand but not before the crush had injured two fingers of his right hand. The driver was taken to the Marmul PAC clinic where the doctor treated him and then referred him to Salalah hospital for X Rays which diagnosed him as having a fracture of the middle finger.INJURY:IP having middle finger fracture
13 Accident Location: Cactus Premier Drilling, Fahud area. Back to Main PageLTI NotificationLTINo 12201413thMarchAccident Location: Cactus Premier Drilling, Fahud area.WHAT HAPPENED:Whilst securing tubular pipes on a trailer at MB completion workshop in Fahud, the IP lost his balance and fell from the trailer bed (1.8 m height). He was immediately transferred to PDO clinic for first aid, after which he was transferred to Nizwa Hospital for further treatment. X-rays showed forearm fracture and dislocation of the right elbow joint. The IP was discharged with a cast on the right elbow.INJURY:IP having fracture and dislocation of the right elbow joint.
14 LTI Notification No 13 LTI 13th March 2014 Back to Main PageLTI NotificationLTINo 13201413thMarchAccident Location: Lekhwair, Oman Oil Marketing sub contractor of KCA Deutag.WHAT HAPPENED:The (IP) and his colleague (the driver, unhurt) were in their way back to Muscat after they have delivered engine oil drums to PDO Rig-11. The driver faced some sand dunes on the road where he was not able to see them from far due to windy and bad weather. The truck slipped out of the road when drove over the dunes and lost control. Police rescued them and took them to PDO Lekhwair clinic and later on both of them were sent by the ambulance to Ibri hospital. The driver was discharged after the medical examination but the helper suffered fracture of L1 vertebra and canal compromise due to fragments into the spinal canal.INJURY:IP having fracture of L1 vertebra and canal compromiseSand Dunes
15 Accident Location: Yibal, SOS (Contractor for PDO labs). Back to Main PageLTI NotificationLTINo 14201423rdMarchAccident Location: Yibal, SOS (Contractor for PDO labs).WHAT HAPPENED:IP was carrying out analytical measurement when manhole cover blew out flashing the content of the chemical drain causing burns on IP eyes. IP is still admitted in hospital for further observation.INJURY:IP suffering chemical eye injuries.
16 Accident Location: SAIH RAWL, OFSAT . Back to Main PageLTI NotificationLTINo 15201426thMarchAccident Location: SAIH RAWL, OFSAT .WHAT HAPPENED:An Ofsat oil field truck was approaching a left hand turn to Rig 85 which was based just off the Saih Rawl to Barik graded road. A diesel tanker had travelled along the road in the opposite direction and had left pockets of dust lingering in the air along the road. The junction to the rig was shrouded in dust and as the Ofsat truck turned left at the junction a Galfar 3 tonne canter approaching from the opposite direction collided with the truck which was across his lane.The canter driver and its two passengers were taken initially to the Galfar clinic and then to the Qarn Alam PAC Clinic before being transferred to Nizwa Hospital where X-rays revealed that the driver had suffered multiple fractures to both his legs. He had also suffered a strain to his left lower chest and his left elbow. One of the passengers also sustained abrasions on his neck and left knee. The second passenger of the canter and the Ofsat driver escaped without injuries.INJURY:IP suffering multiple fractures to both his legs and a strain to his left lower chest and his left elbow.
17 Accident Location: RIMA SMALL FIELDS, ABRAJ ENERGY. Back to Main PageLTI NotificationLTINo 16201431stMarchAccident Location: RIMA SMALL FIELDS, ABRAJ ENERGY.WHAT HAPPENED:After completing maintenance of the rig’s mud pump the crew turned it back on. The Derrick Man who was part of the mechanical crew noticed an abnormal noise coming from the pump and to identify the source of the noise he walked around the pump checking it. As he walked up to the pump’s external rotating crankshaft he was struck by a rotating metal bar which had inadvertently been left connected to the crankshaft. The bar had been used to manually rotate the crankshaft when it had no power and the crew had forgot to remove it after they had finished. He was knocked unconscious and was found on the ground by the rig crew.He was taken to the rig clinic for initial treatment and then transferred to Haima Hospital where he was diagnosed as having a fractured right leg and injuries to his left hand. The doctor referred him on to Nizwa Hospital for further treatment.INJURY:IP suffering fracture right leg and injuries to his left hand.Mud PumpCrankshaft rodRotating metal bar that hit the IP
18 Accident Location: Yibal, MB Petroleum Services . Back to Main PageLTI NotificationLTINo 17201430thMarchAccident Location: Yibal, MB Petroleum Services .WHAT HAPPENED:After rigging down the Wireline equipment, the Wireline tools were being loaded onto a Hiab truck. During the loading process, the truck driver noticed that a 12” well head crossover had incorrectly been placed vertically on the back of the truck. He attempted to push the crossover over into a horizontal position with his left foot whilst his right foot was positioned on a lubricator. Despite holding the side of the truck for balance, as he pushed the cross over his right foot slipped off the lubricator, causing him to fall over and his left wrist struck another lubricator on the truck.He was immediately taken to PDO Yibal clinic for first aid treatment and then transferred to Ibri Hospital for further treatment where X-rays revealed he had fractured his left wrist.INJURY:IP suffering fracture of left wrist.
19 Accident Location: Nimr, Dalma Energy Rig 47 . Back to Main PageLTI NotificationLTINo 18201402ndAprilAccident Location: Nimr, Dalma Energy Rig 47 .WHAT HAPPENED:During a rig up operation the crane operator needed to leave the crane operating cabin towards driving cabin. To do this he had to first step down onto the floor of the crane before climbing down the fixed ladders attached to the side of the crane to the ground. Whilst descending from the cab his left foot slipped and he did not have sufficient grip on the handholds to prevent his loss of balance. He fell 1.3 meters down to the ground, landing heavily on his left hand.He was taken immediately to the rig camp clinic for treatment and after consultation with the Marmul PDO clinic doctor he was transferred to Salalah hospital where X-rays revealed he had fractured both his left wrist and forearm.INJURY:IP suffering fracture of left wrist and forearm.HandholdCrane floor, where he fell fromFixed ladders
20 Accident Location: Bahja, Dalma Energy Rig-58 . Back to Main PageLTI NotificationLTINo 19201406thAprilAccident Location: Bahja, Dalma Energy Rig-58 .WHAT HAPPENED:The Tool Pusher was on the rig floor in preparation for circulation and pulling out of hole. Whilst on the rig floor he needed to go and check the shakers but as he walked past the rotary table his footing slipped, his ankle twisted and he fell to the ground on the rig floor. He was immediately taken to the rig camp clinic for treatment by the medic and then transferred to Haima Hospital where X-rays revealed he had fractured his right lower leg.INJURY:IP suffering fracture of right lower leg.
21 Accident Location: Nimr NRPS, Wood Group CCC. Back to Main PageLTI NotificationLTINo 20201406thAprilAccident Location: Nimr NRPS, Wood Group CCC.WHAT HAPPENED:The IP and his helper were carrying out hot bolting on the fire water tank T4808 pipe line flanges at NRPS as pre-shutdown activity. The IP was initially hammering the impact spanner to loosen nuts while the helper was holding the combination spanner on the lower nut. The IP got tired and asked the helper to do the hammering (switching roles). Whilst the helper was hammering to loosen the bolts, the IP observed that the impact spanner was getting loose and instinctively attempted to put it back without communicating with the helper to stop hammering. The IP got his right index finger hit by the hammer and he was immediately taken to Tawoos clinic. After consultation with Marmul PDO clinic doctor, the IP was transferred to Haima hospital where X-rays revealed fracture of distal phalanx right index finger. INJURY:IP suffering fracture of distal phalanx right index finger.Spanner being struckflangesIP fingerHammer
22 Accident Location: Rima, Weatherford. Back to Main PageLTI NotificationLTINo 21201426thAprilAccident Location: Rima, Weatherford.WHAT HAPPENED:The incident occurred when a joint of drill pipe with a scraper attached to it was lifted with the forklift, using a single webbing sling. The IP was guiding this load to be placed on supports on the ground when he stepped backwards and tripped over another joint of pipe. When he fell he tried to support himself on the sling which then came off the fork and the joint with the scraper fell on his left foot.He was immediately taken to the STS Amal clinic for first aid, and then transferred to Salalah Hospital where X-rays revealed he had fractured both bones in his left leg.INJURY:IP suffering fracture of left lower leg.Fork sling came offWebbing slingSupports where the load should be loaded
23 Accident Location: Lekhwair, Al Bunyaan subcontractor for EMC. Back to Main PageLTI NotificationLTINo 2220147thMayAccident Location: Lekhwair, Al Bunyaan subcontractor for EMC.WHAT HAPPENED:The technician was repairing one of the A/C chiller units in the Lekhwair Pumping Station at substation 10 and in doing so he needed to check the belts tension. While doing that his left hand fingers got trapped between the belts and the pulley. This caused injury on three fingers of his left hand.He was immediately taken to Lekhwair PAC clinic for first aid, and then escorted to Ibri Hospital where diagnosed as Complete amputation of the distal phalanx of the left little finger. Partial amputation of the distal phalanx of the ring finger. He was taken by his company to Khoula hospital and then he discharged himself to continue treatment back in India.INJURY:.IP suffering amputation and fracture of three fingers.The beltThe pulleyPoint of trapped